1、电动葫芦穿用的滑车，其边缘不应有破裂和缺口。

The pulley of electric gourd is worn and the edge should not be broken and broken.

2、钢丝绳在运动中不要和其它物件相摩擦，更不应与钢边的边缘斜拖，以免钢板的棱角割断钢丝绳，直接影响钢丝绳的使用寿命。

2, wire rope friction don't and other objects in motion, more should not be with the edge of the oblique dragging steel edge, lest plate edges cut wire rope, directly affects the service life of wire rope.

3、在高温的物体上使用钢丝绳时，必须采用隔热措施，因为钢丝绳在受到高温后其强度会大大降低。

When using a wire rope on a high temperature object, it must be insulated because the strength of the wire rope will be greatly reduced after it is subjected to high temperature.

4、电动葫芦在使用过程中必须经常检查其钢丝绳强度，一般至少六个月就必须进行一次全面检查或做强度试验。

The electric gourd must check the strength of its steel wire frequently during the use of the electric gourd, and at least six months must undergo a thorough examination or strength test.

5、使用过程中严禁超负荷使用，不应受冲击力，在捆扎或吊运需物时，要注意不要使钢丝绳直接和物体的快口棱锐角相接触，在它们的接触处要垫以木版，帆布、麻袋或其他衬垫物以防止物件的快口棱角损坏钢丝绳而产生设备和人生事故。

5, in the process of using it is strictly prohibited to use overtime and should not be affected by the impact, when strapping or lifting needs, be careful not to make the steel wire rope direct contact and fast mouth acute edges of the object, at their contact pad to wood, canvas, sacks, or some other fast mouth lining in order to prevent the object edge damage steel wire rope and produce equipment and the accident of life.

6、电动葫芦在使用过程中，如出现长度不够时，必须采用卸扣连接，严格禁止用钢丝绳头穿细钢丝绳的方法接长吊运物件，以免由此而产生的剪切力。

6, electric hoist in use process, such as the length is not enough, must adopt shackle connection, strictly prohibited to use wire wear thin wire rope method of extension lifting objects, so as to avoid the resulting shear force.

7、电动葫芦在使用一段时间后，钢丝绳必须加润滑油，一方面可以防止钢丝绳生锈，另一方面，钢丝绳在使用过程中，它的每股子绳之间同一股中的钢丝与钢丝间都会相互产生滑动摩擦特别是在钢丝绳受弯曲力时，这种摩擦更加激励，加了润滑油后就可以减少这种摩擦。

7, electric hoist in use after a period of time, wire rope must add lubricant, on the one hand, can prevent rust, wire rope, on the other hand, steel wire rope in use process, a share of its rope between steel wire and steel wire of the same stock between each other to produce sliding friction, especially by bending force in wire rope, the friction more incentive, after add the lubricating oil can reduce the friction.

8、钢丝绳存放时，要按上述方法将钢丝绳上的脏物清洗干净后上好润滑油，再盘绕好，存放在干燥的地方，在钢丝绳的下面垫以木版或枕木，定期进行检查。

8, wire rope storage, according to the above method after the dirt cleaned on the steel wire rope for oil, coiled again good, stored in a dry place, at the bottom of the steel wire rope gasket to block or sleepers, check regularly.

9、钢丝绳在使用过程中，尤其注意防止钢丝绳与电焊线相接触。因碰电后，钢丝绳会损坏，影响作业的顺利进行。

The wire rope is used in the process of use, especially in preventing the wire rope from being in contact with the electric welding wire. The wire rope will be damaged and the operation will be carried out smoothly.

10、注意进行检查有无断裂破坏情况及其是否使用，或需调换新绳，确保安全。

Pay attention to check for broken and damaged condition and whether to use, or exchange new rope to ensure safety.