联系我们
公司名称：XXX
电话：XXX
手机：XXX
联系人：XXX
地址：XXX
新闻动态
防爆电动葫芦安全操作规程
1、 电动葫芦操作人员必须经过培训，没有培训者不得随意开动。
1, electric hoist operators must be trained, and no trainers are allowed to start at will.
2、 使用前应检查开关、电器、机械部分是否完好。
2, before use, check whether switches, electrical appliances and mechanical parts are intact.
3、 吊运工件前应先开动空车，检查限位器，运转正常后开始工 作。
3, before lifting the workpiece, the empty car should be opened first, and the limiter should be checked to start work after normal operation.
4、 吊运工件时必须吊挂牢固平稳，吊运前先稍离地面。经试吊 无问题后再吊运。
4. When lifting the workpiece, it must be hung firmly and smoothly before leaving the ground before lifting. The test hanger is lifted without any problems.
5、 不允许倾斜起吊及做水平拖拉工具使用。
5, it is not allowed to tilt and lift and use horizontal drag tools.
6、 不准倾斜起吊和作水平拖拉使用，严禁吊物从人员头上经 过。
6. It is not allowed to tilt and lift and use horizontal drag.
7、 严禁将重物吊在钩尖处或钩结不牢起吊
7, it is strictly prohibited to hang heavy objects at hook points or hook up.
8、 吊运工件时应检查吊具是否符合规定，不得超负荷使用。
8. When lifting the workpiece, check whether the spreader is in conformity with the regulations and not overload.
9、 限位系防止吊钩上升和下降的安全装置，严禁把限位当开关 使用。
9, the limit system prevents the lifting and descending of the hook. It is strictly forbidden to use the limit as the switch.
10、 严禁长时间载荷悬与空中。
10, no long time load is suspended.
11、 工作完毕后，要将电动葫芦开至固定位置并切断电源
11, after the work is finished, the electric hoist should be opened to a fixed position and cut off the power supply.
12、 防爆电动葫芦要有专人操作，操作者应掌握有关防爆安全的 规程。
12. Explosion-proof electric hoist should be operated by a special person. The operator should have the rules for explosion-proof safety.
13、 防爆电动葫芦应至少每10天检查一次，发现故障要采取措 施，并加以记录。
13. Explosion-proof electric hoist should be inspected at least once every 10 days. Measures should be taken and recorded when faults are found.
14、 检查防爆电动机、制动器、磁力起动器、限位开关前必须切 断电源。
14, check the explosion-proof motor, brake, magnetic starter, limit switch must be cut off before the power supply.
15、 防爆电动葫芦的钢丝绳每10天至少润滑一次。
15. The wire rope of explosion-proof electric hoist is lubricated at least once every 10 days.
16、 防爆电动葫芦使用完毕应停放指定位置，吊钩升至离地面足够的高度，以免影响地面人员活动。
16. The explosion-proof electric hoist should be parked at a designated position after use, and the hook should be lifted to a sufficient height from the ground to avoid affecting the activities of the ground personnel.
1, electric hoist operators must be trained, and no trainers are allowed to start at will.
2、 使用前应检查开关、电器、机械部分是否完好。
2, before use, check whether switches, electrical appliances and mechanical parts are intact.
3、 吊运工件前应先开动空车，检查限位器，运转正常后开始工 作。
3, before lifting the workpiece, the empty car should be opened first, and the limiter should be checked to start work after normal operation.
4、 吊运工件时必须吊挂牢固平稳，吊运前先稍离地面。经试吊 无问题后再吊运。
4. When lifting the workpiece, it must be hung firmly and smoothly before leaving the ground before lifting. The test hanger is lifted without any problems.
5、 不允许倾斜起吊及做水平拖拉工具使用。
5, it is not allowed to tilt and lift and use horizontal drag tools.
6、 不准倾斜起吊和作水平拖拉使用，严禁吊物从人员头上经 过。
6. It is not allowed to tilt and lift and use horizontal drag.
7、 严禁将重物吊在钩尖处或钩结不牢起吊
7, it is strictly prohibited to hang heavy objects at hook points or hook up.
8、 吊运工件时应检查吊具是否符合规定，不得超负荷使用。
8. When lifting the workpiece, check whether the spreader is in conformity with the regulations and not overload.
9、 限位系防止吊钩上升和下降的安全装置，严禁把限位当开关 使用。
9, the limit system prevents the lifting and descending of the hook. It is strictly forbidden to use the limit as the switch.
10、 严禁长时间载荷悬与空中。
10, no long time load is suspended.
11、 工作完毕后，要将电动葫芦开至固定位置并切断电源
11, after the work is finished, the electric hoist should be opened to a fixed position and cut off the power supply.
12、 防爆电动葫芦要有专人操作，操作者应掌握有关防爆安全的 规程。
12. Explosion-proof electric hoist should be operated by a special person. The operator should have the rules for explosion-proof safety.
13、 防爆电动葫芦应至少每10天检查一次，发现故障要采取措 施，并加以记录。
13. Explosion-proof electric hoist should be inspected at least once every 10 days. Measures should be taken and recorded when faults are found.
14、 检查防爆电动机、制动器、磁力起动器、限位开关前必须切 断电源。
14, check the explosion-proof motor, brake, magnetic starter, limit switch must be cut off before the power supply.
15、 防爆电动葫芦的钢丝绳每10天至少润滑一次。
15. The wire rope of explosion-proof electric hoist is lubricated at least once every 10 days.
16、 防爆电动葫芦使用完毕应停放指定位置，吊钩升至离地面足够的高度，以免影响地面人员活动。
16. The explosion-proof electric hoist should be parked at a designated position after use, and the hook should be lifted to a sufficient height from the ground to avoid affecting the activities of the ground personnel.
